1st Gen R53 Cooper S Most liked posts in thread: AC Compressor on it's way out

Page 1 of 2
  1. Nathan

    Nathan Founder

    Mar 30, 2009
    25,144
    10,052
    113
    Writer
    Short North
    Ratings:
    +10,069 / 0 / -0
    #2 Nathan, Jul 13, 2009
    It's not cheap, about a grand I think. I had one replaced under warranty as the clutch burned up in it. Might want to try the warranty route if still covered. At least point out the issue to the dealer so it's on record.

    64-52-6-918-122 is the part #. List is around 900.00
     
  2. mini_racer

    mini_racer Well-Known Member

    May 4, 2009
    1,046
    57
    48
    Engr Manager
    Austin, TX
    Ratings:
    +57 / 0 / -0
    #3 mini_racer, Jul 13, 2009
    Damn that is not cheap, I might need to try the slightly pre-owned route as my warranty has now expired. Buying used for an item like this is a gamble though. I have seen them used for $200, but they were a few years old and ~35K miles.

    It might be a decent option though.

    Oh BTW, how did yours go out? did it make any noises, smells, etc. Did the clutch just burn up and then stopped turning the actual pump/compressor, so it suddenly stopped cooling?
     
  3. nabeshin

    nabeshin New Member

    Jun 8, 2009
    409
    1
    0
    Lincoln, NE
    Ratings:
    +1 / 0 / -0
    #4 nabeshin, Jul 13, 2009
    My a/c compressor has been making that whining sound just as you describe for the past 20,000 miles and it still works. When it fails though, I'll get one of those idler pulleys and remove the compressor.
     
  4. mini_racer

    mini_racer Well-Known Member

    May 4, 2009
    1,046
    57
    48
    Engr Manager
    Austin, TX
    Ratings:
    +57 / 0 / -0
    #5 mini_racer, Jul 13, 2009
    So, if you are going to remove the compressor and not replace, does that mean you do not use it now? So it makes the noise all the time, even when off? Hmmm, mine only makes the noise when the AC is running.
     
  5. k-huevo

    k-huevo Club Coordinator

    May 6, 2009
    683
    159
    0
    Pipe Creek, Texas
    Ratings:
    +159 / 0 / -0
    #6 k-huevo, Jul 13, 2009
    That’s just the way it is. You’ll also notice it doesn’t roar at night. If it is cooling that’s all that matters. So far malfunctioning behaviors haven’t been mentioned, so enjoy it while it lasts.
     
  6. mini_racer

    mini_racer Well-Known Member

    May 4, 2009
    1,046
    57
    48
    Engr Manager
    Austin, TX
    Ratings:
    +57 / 0 / -0
    #7 mini_racer, Jul 14, 2009
    No problem on enjoying it while it lasts, I am certainly not going to touch it until it dies. Just wondering how long I might have, and if this is the predominant failure mode.
     
  7. mdbsat

    mdbsat New Member

    May 7, 2009
    38
    1
    0
    Finance
    San Antonio
    Ratings:
    +1 / 0 / -0
    #8 mdbsat, Jul 14, 2009
    Mine sounds like a Harrier jet. I am just going to wait and see how long this bad boy lasts........
     
  8. Steve

    Steve Administrator
    Staff Member Articles Moderator

    Apr 23, 2009
    12,154
    3,164
    113
    Maryland, USA
    Ratings:
    +3,166 / 0 / -0
    #9 Steve, Jul 14, 2009
    Does the sound change pitch along with engine speed?
     
  9. mini_racer

    mini_racer Well-Known Member

    May 4, 2009
    1,046
    57
    48
    Engr Manager
    Austin, TX
    Ratings:
    +57 / 0 / -0
    #10 mini_racer, Jul 14, 2009
    Yes, barely noticeable at idle, and then can really hear it above 3.5K. And so from the start I knew it was something hanging off the serpentine belt: AC, alternator, idler pulley, etc. Then it was pretty much locked-in as AC compressor when turning off the AC made the noise completely stop.
     
  10. k-huevo

    k-huevo Club Coordinator

    May 6, 2009
    683
    159
    0
    Pipe Creek, Texas
    Ratings:
    +159 / 0 / -0
    #11 k-huevo, Jul 14, 2009
    The whine/roar is not indicative of failure if the AC continues to function normally. As you mentioned, it only occurs for you at very high ambient temps, and street stop & go city driving; so does mine. Those with removed cowl partitions notice it more than others. My AC clutch went at 90,000 plus miles some have gone 200,000, some less than 50,000. A how-to for if or when the time comes [ame=http://www.lonestarminiclub.com/forums/showthread.php?t=571]AC Compressor, Dryer & Expansion Valve Install - Lone Star Mini Club Forums[/ame]
     
  11. mini_racer

    mini_racer Well-Known Member

    May 4, 2009
    1,046
    57
    48
    Engr Manager
    Austin, TX
    Ratings:
    +57 / 0 / -0
    #12 mini_racer, Jul 14, 2009
    Thanks for that, I will check out the link. And to be clear the AC system is cooling just fine. It is just getting noisy. Maybe I need to make the AC noise my new shift point for city driving. :^)
     
  12. Steve

    Steve Administrator
    Staff Member Articles Moderator

    Apr 23, 2009
    12,154
    3,164
    113
    Maryland, USA
    Ratings:
    +3,166 / 0 / -0
    #13 Steve, Jul 14, 2009
    Last edited: Jul 14, 2009
    Yep, that nails it. I may be the odd example here, but you can hope I suppose. Those symptoms are the same as my Cooper had for a year or two, then it stopped. That is, the noise went away. It's been another three or four years now and still working. I thought I'd lost the compressor last spring but it turned out the body shop overcharged the system when they put my car back together....fixed the charge problem and it's working fine again.

    I asked about the noise on NAM about four or five years ago and the overwhelming chorus of replies was something like "that's your supercharger, DUH!" Me: "Ummm, my Cooper doesn't have a supercharger." Reply: sound of crickets chirping.
     
  13. BThayer23

    BThayer23 Well-Known Member

    Jun 12, 2009
    1,315
    154
    63
    Civil Engineer
    Durham, NC
    Ratings:
    +155 / 0 / -0
    #14 BThayer23, Jul 14, 2009
    I have the same problem. It gets worse when the AC's running full blast, and definitely in lower gears at higher RPM's it's worse. Almost sounds like a vacuum cleaner. This happened to me last summer, and then it went away for a while... also known as winter. :lol:
     
  14. nabeshin

    nabeshin New Member

    Jun 8, 2009
    409
    1
    0
    Lincoln, NE
    Ratings:
    +1 / 0 / -0
    #15 nabeshin, Jul 14, 2009
    My system is exactly like what you are all describing. Only has the whine when turned on, it is rpm dependent, louder above 3.5k, and is more pronounced in hot weather.
     
  15. mini_racer

    mini_racer Well-Known Member

    May 4, 2009
    1,046
    57
    48
    Engr Manager
    Austin, TX
    Ratings:
    +57 / 0 / -0
    #16 mini_racer, Jul 14, 2009
    While misery does like company............ That noise is NOT normal and we should not be experiencing this compressor whirring noise, even if the unit still works fine, at least for the moment. Not that I can do anything about it, but this is a clear reliability issue. Nothing to do but wait for the defect to mature into a full fledged failure.:mad2:
     
  16. fasteddie

    fasteddie New Member

    May 12, 2009
    5
    0
    0
    MINI Technician
    Red Oak, TX
    Ratings:
    +0 / 0 / -0
    #17 fasteddie, Jul 14, 2009
    I'VE HEARD THE COMPRESSORS DO THAT. YOU MIGHT TRY AN A/C SERVICE. EVACUATE AND RECHARGE, AND ADD SOME OIL. I FOUND REBUILT UNITS FOR $600.00, 1 YR WARRANTY, WITH NEW CLUTCH.
     
  17. mini_racer

    mini_racer Well-Known Member

    May 4, 2009
    1,046
    57
    48
    Engr Manager
    Austin, TX
    Ratings:
    +57 / 0 / -0
    #18 mini_racer, Jul 22, 2009
    Well, I just paid a visit to my local dealership today and through some effort, I was finally able to reproduce the compressor noise with the tech riding shotgun.

    I am now the proud owner of a new AC compressor. Yeah! :D
     
  18. mdbsat

    mdbsat New Member

    May 7, 2009
    38
    1
    0
    Finance
    San Antonio
    Ratings:
    +1 / 0 / -0
    #19 mdbsat, Sep 10, 2011
    Now I wish mine sounded like a harrier jet. My AC only blows air into the cabin that is at whatever temperature the Engine bay is at. It's nice in the morning until my car heats up.

    Terry, it looks like the dealer helped you out. That's not am option in my case. What is everyone's opinion on getting a new compressor that is not OEM? I have seem the whole kit: expansion valve, compressor etc for $525. Is this too good to be true? I guess I could ride this out until after winter but in san Antonio that is about one month.

    This could be the nail in the coffin as my wife wants me to sell the car now and stop putting money into it. :( I cannot let this happen! Anyway, thoughts and opinions would be welcomed.

    Edit: just realized this was quite a thread necro.
     
  19. Rae

    Rae Club Coordinator

    Oct 14, 2010
    907
    77
    0
    teacher for severely/multiply disabled students
    Oregon
    Ratings:
    +77 / 0 / -0
    #20 Rae, Sep 10, 2011
    Before you put in a new compressor, go to the autoparts store and buy a recharge kit. It'll come with a pressure valve, stop leak mixed in, and a quick connect. All for about $20. My AC was just blowing air, no noise and a charge did the trick. Even if I have a leak and have to recharge it once a year, for $1500 to fix it , I can go 75 years before it costs the same :)
     
  20. mdbsat

    mdbsat New Member

    May 7, 2009
    38
    1
    0
    Finance
    San Antonio
    Ratings:
    +1 / 0 / -0
    #21 mdbsat, Sep 12, 2011
    I did that before the AC stopped working. The guy at the shop I took it too this weekend said never to use those with any kind of sealant on our cars. He thinks thats what killed my AC:(
     
Page 1 of 2