1st Gen R53 Cooper S Most liked posts in thread: Power Steering Motor Fan

  1. Crashton

    Crashton Club Coordinator

    Jun 4, 2009
    19,445
    10,063
    113
    Retired old fart
    Hooterville Ohio USA
    Ratings:
    +11,706 / 3 / -0
    #4 Crashton, Jan 3, 2016
    It was bound to happen one day! :D
     
  2. MCS02

    MCS02 Moderator
    Staff Member Articles Moderator Supporting Member

    Jul 31, 2009
    11,349
    6,316
    113
    Male
    Ratings:
    +8,132 / 10 / -3
    #5 MCS02, Jan 3, 2016
    Don't get carried way, sparky! :lol:
     
  3. nkfry

    nkfry New Member
    Motoring Alliance Sponsor

    Aug 12, 2013
    93
    147
    0
    MINI Specialist at Detroit Tuned
    Roseville, MI
    Ratings:
    +147 / 0 / -0
    #7 nkfry, Jan 7, 2016
    Since the current fan is seizing I would also advise you to check fuse 41 in the drivers footwell as it is probably blown.

    You will also need to make sure that your cooling fan relay is working properly, the PS fan is tied in with the cooling fan and if the relay is failed you may not get PS fan actuation.
     
  4. Crashton

    Crashton Club Coordinator

    Jun 4, 2009
    19,445
    10,063
    113
    Retired old fart
    Hooterville Ohio USA
    Ratings:
    +11,706 / 3 / -0
    #2 Crashton, Jan 3, 2016
    If it was me I'd replace it now. You are relying on it to keep the PS motor cool. The fan is much easier to replace than the PS motor. Much cheaper too.
     
  5. matchframe

    matchframe Member

    Aug 3, 2009
    67
    15
    8
    Video Tech for Boeing at NASA Houston
    Dickinson, Texas
    Ratings:
    +15 / 0 / -0
    #9 matchframe, Jan 8, 2016
    The new fan showed up yesterday from eMiniparts.com and I was able to replace it in about 10 minutes. The old fan definitely had bad bearings.

    The fuse was blown. I replaced it and ran the engine with the A/C on I could see that the steering motor fan was operating.

    Thanks for pointing out the fuse !! :Thumbsup:
     
  6. MCS02

    MCS02 Moderator
    Staff Member Articles Moderator Supporting Member

    Jul 31, 2009
    11,349
    6,316
    113
    Male
    Ratings:
    +8,132 / 10 / -3
    #3 MCS02, Jan 3, 2016
    It only runs all the time when the AC is on, other times when it is under a load, I believe. If you spin it and it feels notchy then you need to replace it. Crashton is correct better safe than sorry.
     
  7. 00Mini

    00Mini Well-Known Member

    Feb 24, 2013
    24,011
    2,262
    113
    Retired
    Ratings:
    +3,345 / 7 / -5
    #10 00Mini, Jan 8, 2016
    Good to hear everything went well for you !!
     
  8. Stinch

    Stinch New Member

    Jun 24, 2015
    24
    21
    0
    Trumbull, CT
    Ratings:
    +21 / 0 / -0
    #12 Stinch, Jan 14, 2016
    Thanks for pointing this out. I had my p/s pump and fan replaced under warranty last spring. Guess the dealer never checked for function. I went out to the garage tonight to check and sure enough my #41 5A fuse was blown.

    Cheers
    Rich
     
  9. matchframe

    matchframe Member

    Aug 3, 2009
    67
    15
    8
    Video Tech for Boeing at NASA Houston
    Dickinson, Texas
    Ratings:
    +15 / 0 / -0
    #6 matchframe, Jan 3, 2016
    Thanks ! :Thumbsup:
     
  10. matchframe

    matchframe Member

    Aug 3, 2009
    67
    15
    8
    Video Tech for Boeing at NASA Houston
    Dickinson, Texas
    Ratings:
    +15 / 0 / -0
    #8 matchframe, Jan 8, 2016
    I will check on that.

    Thanks !!
     
  11. BlimeyCabrio

    BlimeyCabrio Oscar Goldman of MINIs
    Lifetime Supporter

    May 4, 2009
    3,532
    2,896
    113
    Professional Facilitator and Alignment Consultant
    Holly Springs, NC
    Ratings:
    +2,896 / 0 / -0
    #11 BlimeyCabrio, Jan 8, 2016
    Good job!